# Commission Implementing Decision (EU) 2020/2009 of 22 June 2020 establishing the best available techniques (BAT) conclusions, under Directive 2010/75/EU of the European Parliament and of the Council on industrial emissions, for surface treatment using organic solvents including preservation of wood and wood products with chemicals (notified under document C(2020) 4050) (Text with EEA relevance), Division 1.3: BAT conclusions for the coating of other metal and plastic surfaces

Extent: E+W+S+N.I.

The emission levels given below for coating of other metal and plastic surfaces are associated with the general BAT conclusions described in Section 1.1. The emission levels given below may not apply where metal and/or plastic automotive components are coated in a vehicle coating plant and these emissions are included in the calculation of the total VOC emissions for the coating of vehicles (see Section 1.2).
Table 9
BAT-associated emission levels (BAT-AELs) for total emissions of VOCs from the coating of other metal and plastic surfaces
Parameter
Process
Unit
BAT-AEL(Yearly average)
Total VOC emissions as calculated by the solvent mass balance
Coating of metal surfaces
kg VOCs per kg of solid mass input
< 0,05–0,2
Coating of plastic surfaces
< 0,05–0,3
The associated monitoring is given in BAT 10.
As an alternative to the BAT-AELs in Table 9, the BAT-AELs in both Table 10 and Table 11 may be used.
Table 10
BAT-associated emission level (BAT-AEL) for fugitive emissions of VOCs from the coating of other metal and plastic surfaces
Parameter
Unit
BAT-AEL(Yearly average)
Fugitive VOC emissions as calculated by the solvent mass balance
Percentage (%) of the solvent input
< 1–10
The associated monitoring is given in BAT 10.
Table 11
BAT-associated emission level (BAT-AEL) for VOC emissions in waste gases from the coating of other metal and plastic surfaces
The upper end of the BAT-AEL range is 35 mg C/Nm3 if techniques are used which allow the reuse/recycling of the recovered solvent.
For plants using BAT 16 (c) in combination with an off-gas treatment technique, an additional BAT-AEL of less than 50 mg C/Nm3 applies to the waste gas of the concentrator.
Parameter
Unit
BAT-AEL(Daily average or average over the sampling period)
TVOC
mg C/Nm3
1–20
The associated monitoring is given in BAT 11.

---
Source: https://www.legislation.gov.uk/eudn/2020/2009/annex/division/1/division/1.3 (the official version)
Page: https://openlegislation.uk/eu-decision-2020-2009/annex/division-1/division-1.3
Contains public sector information licensed under the Open Government Licence v3.0. Source: legislation.gov.uk, The National Archives.