# Third Commission Directive of 27 September 1983 on the approximation of the laws of the Member States relating to methods of analysis necessary for checking the composition of cosmetic products (83/514/EEC), Division 5.2.4: Preparation of the sample

Extent: E+W+S+N.I.

Weigh accurately into a 50 ml centrifuge tube enough of the sample to give a presumed quantity of 50 to 70 mg of mercaptoacetic acid. Acidify with a few drops of hydrochloric acid (5.2.2.2) to obtain a pH of about 3.
Add 5 ml of demineralized water and 10 ml of acetate buffer solution (5.2.2.6).
Check with pH paper that the pH value is about 5. Then add 5 ml of cadmium di(acetate) solution (5.2.2.4).
Wait 10 minutes and then centrifuge for at least 15 minutes at 4 000 g. Remove the supernatant liquid which may contain an insoluble fat (in the case of cream products). This fat cannot be confused with the thiols which collects in a compact mass at the bottom of the tube. Check that no precipitation occurs when a few drops of cadmium di(acetate) solution (5.2.2.4) are added to the supernatant.
Where earlier identification revealed no reducing agents other than the thiols, check by iodometry that the thiol present in the supernatant liquid does not exceed 6 to 8 % of the initial quantity.
Introduce 10 ml of methanol (5.2.2.3) into the centrifuge tube containing the precipitate and finely disperse the precipitate with a stirring rod. Centrifuge again for at least 15 minutes at 4 000 g. Pour off the supernatant and check for the absence of thiols.
Wash the precipitate a second time by the same procedure.
Still using the same centrifuge tube, add:
2 ml of methyl octanoate solution (5.2.2.5),
5 ml of hydrochloric acid in methanol (5.2.2.7).
Completely dissolve the thiols (a little insoluble matter may persist from the excipient). This is solution ‘S’.
With an aliquot of this solution, check iodometrically that the thiols content is at least 90 % of that obtained in 5.1.

---
Source: https://www.legislation.gov.uk/eudr/1983/514/annex/division/14/division/5/division/5.2/division/5.2.4 (the official version)
Page: https://openlegislation.uk/eu-directive-1983-514/annex/division-14/division-5/division-5.2/division-5.2.4
Contains public sector information licensed under the Open Government Licence v3.0. Source: legislation.gov.uk, The National Archives.