# Fertilisers (Sampling and Analysis) Regulations (Northern Ireland) 1996, Paragraph 6: PROCEDURE


Treatment of the solution
6.1 Using a pipette take an aliquot portion of fertiliser extract (see the Table) containing about 0.01 g of P2O5 and transfer to a 500 ml Erlenmeyer flask. Add 15 ml concentrated nitric acid (4.1) and dilute with water to about 100 ml.
Hydrolysis
6.2 Bring the contents of the Erlenmeyer flask to the boil slowly and keep at this temperature until hydrolysis is completed (this usually takes 1 hour). Care must be taken to avoid losses by splashing and excessive evaporation which would reduce the initial volume by more than half, by fitting a reflux condenser. After hydrolysis make up to the initial volume with distilled water.
Weighing the crucible
6.3 Dry the filter crucible (5.1) for at least 15 minutes in the drying oven (5.2). Cool the crucible in a desiccator and weigh.
Precipitation
6.4 Heat the acid solution in the Erlenmeyer flask until it begins to boil and then precipitate the quinoline phosphomolybdate by adding 40 ml of the precipitating reagent (4.2.1 or 4.2.2) drop by drop, stirring continuously. Place the Erlenmeyer flask in a steam bath for 15 minutes, shaking from time to time. The solution can be filtered immediately or after it has cooled down.
Filtering and washing
6.5 Filter the solution under vacuum by decantation. Wash the precipitate in the Erlenmeyer flask with 30 ml water. Decant and filter the solution. Repeat this process five times. Quantitatively transfer the rest of the precipitate into the crucible washing it with water. Wash four times with 20 ml water, allowing the liquid to drain from the crucible before each addition.
Drying and weighing
6.6 Wipe the outside of the crucible with a filter paper. Place the crucible in the drying oven (5.2) for approximately 15 minutes. Cool in a desiccator and weigh rapidly, repeat this process until a constant mass is attained.
Blank test
6.7 For each series of determinations, make a blank test under the same conditions (omitting only the sample) and allow for this in the calculation of the final result.
Control test
6.8 Carry out the determination using an aliquot portion of a potassium dihydrogen phosphate solution containing 0.01 g of P2O5.

---
Source: https://www.legislation.gov.uk/nisr/1996/513/schedule/2/part/I/chapter/10./paragraph/6 (the official version)
Page: https://openlegislation.uk/fertilisers-sampling-and-analysis-regulations-northern-ireland-1996/schedule-2/part-I/chapter-10./paragraph-6
Contains public sector information licensed under the Open Government Licence v3.0. Source: legislation.gov.uk, The National Archives.