Division 1.6 BAT conclusions for coil coating
United Kingdom
The emission levels for coil coating given below are associated with the general BAT conclusions given in Section 1.1.
Table 14
BAT-associated emission level (BAT-AEL) for fugitive emissions of VOCs from coil coating
| Parameter | Unit | BAT-AEL(Yearly average) |
|---|---|---|
| Fugitive VOC emissions as calculated by the solvent mass balance | Percentage (%) of the solvent input | < 1–3 |
The associated monitoring is given in BAT 10.
Table 15
BAT-associated emission level (BAT-AEL) for VOC emissions in waste gases from coil coating
| The upper end of the BAT-AEL range is 50 mg C/Nm3 if techniques are used which allow the reuse/recycling of the recovered solvent. | ||
| For plants using BAT 16 (c) in combination with an off-gas treatment technique, an additional BAT-AEL of less than 50 mg C/Nm3 applies to the waste gas of the concentrator. | ||
| Parameter | Unit | BAT-AEL(Daily average or average over the sampling period) |
|---|---|---|
| TVOC | mg C/Nm3 | 1–20f1 f2 |
The associated monitoring is given in BAT 11.
Annotations
Footnotes
- f1
-
The upper end of the BAT-AEL range is 50 mg C/Nm3 if techniques are used which allow the reuse/recycling of the recovered solvent.
- f2
-
For plants using BAT 16 (c) in combination with an off-gas treatment technique, an additional BAT-AEL of less than 50 mg C/Nm3 applies to the waste gas of the concentrator.